>> Canning Tips

Canning - Boiling Water Bath

There are two methods of canning fruits and vegetables: boiling water bath or pressure canning. Low acid vegetables (everything except tomatoes) can harbor heat-resistant bacteria, and should be heated to at least 240°F - a temperature that can only be produced by pressure canning. High acid food, which includes tomatoes, pickled vegetables and most fruits, can be processed at boiling water temperature (212°F).

For the Boiling Water Bath method, you will need:

Boiling water bath canner -- This is basically a large, deep pan with a tight fitting lid. It should be large enough to allow 4 or more inches of "headroom" above the jars.
Wire basket or rack to fit inside the pan and hold your jars.
Tongs to lift jars out of boiling water.
Oven mitts to handle hot jars.
Cooling rack, or several towels.
Kitchen timer.

First: Fill canner halfway with hot water and put the jars into it, either inside the basket, or setting on a rack on the bottom of the pan. Add boiling water to 2 inches above the jars. Be careful not to pour boiling water directly onto the jars.

Second: Cover canner tightly and bring water to a rolling boil. Start the timer (use this chart to determine boiling time) and reduce heat just enough to maintain a rapid boil. Add boiling water throughout if needed.

Third: When time is up, remove jars immediately with the tongs. If necessary, tighten the lids. Set the jars on a cooling rack or layer of towels to cool. Leave space between cooling jars.

After canning, label the jars with their contents and the date they were canned. Store jars in a cool, dark place. Light can cause discoloration and loss of nutrients.

Canning - Jars vs. Cans

Generally canning with glass jars is best, simply because you can see the produce. It's easy to check for damage, leaking, and discoloration. Glass jars are also cheaper, easier to use, and you can reuse them over and over again! Tin cans may not break like a glass jar, but if you use tin cans for canning, you'll need to buy a sealing device.

Glass jars commonly used today have either a porcelain-lined cap, which consists of a screw top and rubber ring, or a self-sealing cap, which consists of a flat lid with sealant around the rim and a screw-on band that holds the lid against the lip of the jar. The band can be reused, but you should use a new lid for each process. Old-fashioned clamp-type jars can still be found, but do not use decorative replicas for canning. With this type, the glass lid and rubber ring are held in place with a long clamp during processing, and then a short clamp is snapped down for a tight seal.

Canning - Packing The Ingredients

Wash all produce prior to packing into containers. Vegetables and large fruits can be cut into pieces and pitted if necessary. Smaller fruits such as berries can be left whole. Fruits can be dipped in asorbic acid (vitamin C) and packed in sugar syrup to preserve their color, texture and flavor.

There are two ways to pack the produce into the jars before processing:

Raw Packed
Pack clean produce tightly into containers and pour on boiling juice, water or syrup. Wipe the rim and sealing ring to remove any food particles, then close the jar and proceed with the canning process.

Hot Packed
Steam or heat vegetables or fruits to boiling in juice, water or syrup, then immediately pack them into the jars. If you are using a porcelain-lined cap jar, wet the rubber ring and fit it against the top/shoulder of the jar. Screw the cap on firmly, then back off one quarter turn. After processing, immediately screw the cap tightly again.

If you are using a self-sealing cap jar, tighten band before processing and don't loosen it again.

Canning Basics

Canning is a great way to preserve vegetables and fruits for your own use or for gifts. The basic principal is simple: during the canning process, food is heated to a high enough temperature to stop the decaying action of enzymes and/or bacteria and other microorganisms in the food. The food is then stored in sterile, airtight containers to prevent contamination.

This isn't a process you should treat carelessly. Contaminated food can cause illness, and botulism isn't something you want to mess with. Always remember these things:

Choose only perfect produce. Overripe or damaged fruits and vegetables are more prone to spoilage.

Your jars, lids and sealing rings should be in good condition and sterile (washed and scalded).

Wash your produce thoroughly before processing.

Know your produce. Be sure to use the correct time, temperature and method of processing for the food you will be canning. Methods are described below, and this chart will help you determine processing times.

After canning, check the seal on every jar to make sure they are air tight - when you push down on a self-sealing lid, it should stay down. Test porcelain lids by turning the jars upside down. If you see a stream of tiny air bubbles, the seal is not air tight.

Don't use foods from any jar that has a foamy or discolored appearance. Watch for bulging or misshapen lids and leaking rims. Throw those jars away.

Home canned vegetables should be boiled before they are served (with the exception of tomatoes).

Canning Times for Fruits and Vegetables

Fruit/Vegetable	Method	Time for Pints	Time for Quarts
Apples	Boiling water bath	15 min hot packed	20 min hot packed
Apricots	Boiling water bath	20 min hot packed 25 min raw packed	25 min hot packed 30 min raw packed
Asparagus	Pressure canning	25 min	30 min
Beets	Pressure canning	30 min	35 min
Berries	Boiling water bath	10 min hot or raw packed	15 min hot or raw packed
Carrots	Pressure canning	25 min	30 min
Cherries	Boiling water bath	10 min hot packed 20 min raw packed	15 min hot packed 25 min raw packed
Corn	Pressure canning	55 min	55 min
Peaches	Boiling water bath	20 min hot packed 25 min raw packed	25 min hot packed 30 min raw packed
Pears	Boiling water bath	20 min hot packed 25 min raw packed	25 min hot packed 30 min raw packed
Plums	Boiling water bath	20 min hot or raw packed	25 min hot or raw packed
Potatoes	Pressure canning	35 min	40 min
Pumpkin	Pressure canning	55 min	90 min
Rhubarb	Boiling water bath	10 min hot packed	10 min hot packed
Snap Beans	Pressure canning	20 min	25 min
Squash	Pressure canning	55 min	90 min
Tomatoes	Boiling water bath	35 min hot packed 40 min raw packed	45 min hot packed 50 min raw packed
From Back to Basics, Reader's Digest

( BACK TO COOKING TIPS HOME )